Winter is Coming: How to Prepare Your Tankless Water Heater

You may be wondering how you can best prepare your tankless water heater for the upcoming cold months; well, we are here to help with that. Below you will find more help broken down by model and how you can be ready for the cold, while keeping your Eccotemp Tankless Water Heater in its best shape come spring.

 Winter_1_small.jpg

First, let’s review the Portables:

L5, L7, & L10

The portable series tankless water heaters are not meant for permanent installation and should always be drained, taken down and stored away in a warm environment when not in use. This helps to keep water from freezing, expanding and busting the pipes inside that are responsible for providing you that lovely hot water.

*DO NOT leave your portable water heater outside in the elements; rain, dust, bugs, and even sometimes mice can find their way into your tankless water heater. This series should NEVER be permanently installed and left outside, especially during the cold and wet weather.

Remember that freeze damage voids your warranty and neither of us want that! Always protect your water heater from the elements!

L5_camper.jpg

Let’s move onto our smaller home units:

FVI12 and i12

Now, just because this water heater is an indoor tankless water heater doesn’t mean that you are 100% safe from freezing temperatures affecting your unit. You still have to be mindful of the incoming water temperatures and just like we’ve done for years with our traditional water heaters, it’s a good practice to leave that faucet dripping when the outside temperatures drop down below 32 degrees F or 0 degrees C. Some folks even open up the cabinets below their sinks to let the heat from the home help keep the pipes below warm. Both the FVI12 and the i12 are not equipped with any “anti-freeze” technology inside, so this “dripping” of the faucet is definitely something you want to practice.

You should also be sure you wrap your piping and valves in insulation material as instructed in your manual. The pipes leading to your unit are just as important as the unit itself.

i12_farm_kitchen.png

If your water heater is at a vacation cabin or place that you don’t plan on visiting for the season, then we recommend treating it the same as a portable unit for preparation: drain, disconnect, and store away in a warm, dry place until you are ready to use it again.

FVI12_yellow_apt.jpg

Notice: Unplugging the electric supply cord does not protect the unit from freeze protection.

Moving onto our larger whole home units:

45H/45HI and EL22/EL22i Series

Both the 45 series and the EL22 series are equipped with an anti-freeze technology built into the water heater to help protect the unit from those harsh and cold freezing temperatures. Keep in mind, that this technology is only meant to protect the unit itself, so if you did not properly prepare your pipes leading to the unit, then you are not fully protecting your unit. These anti-freeze protectors in the water heater will in no way guarantee protection from freeze damage. DO NOT rely on the anti-freezers to fully protect the unit from freezing. Take all precautions to avoid cold damage.

 EL22_green_smaller.jpg

Freezing anywhere in the plumbing system can result in damage to the water heater, such as a rupture in your Heat Exchanger. All pipes must be adequately protected from freezing. Tankless water heaters with Anti-Freezers, like the 45 and EL22, have an automatic heating device and will help to avoid freeze damage, but the power must be kept on. Freezing will occur with no power. In very cold areas and when the temperature is under 32 degrees F, or in event of an ice storm, freezing will occur as the heating power limit is exceeded. If these conditions take place, remember it is important to follow the procedure below:

  1. Shut off the main gas valve and power
  2. Shut off the inlet water valve
  3. Open all faucets
  4. Take the drain valve and allow water to drain for 3 minutes or until the unit is empty
  5. Making sure all water is out, replace the drain valve, and shut off the faucets

Outside_home_45bluehouse.png

The most important thing to remember during the winter is that you should be taking all precautions when it comes to protecting your tankless hot water heater.

 

If at any time during this season you have any questions, feel free to Live Chat with our support team via our website or support page: support.eccotemp.com

Our dedicated team is always happy to help!

Was this article helpful?
1 out of 1 found this helpful
Have more questions? Submit a request

Comments

0 comments

Please sign in to leave a comment.